Product ID:MIL-C-22750E WHITE #37875, F-09P334
MSDS Date:06/20/1994
FSC:8010
NIIN:01-350-2677
Kit Part:Y
MSDS Number: BTTDD

SEAGRAVE COATINGS CORP OF VA

4030 SEAGUARD AVENUE
PORTSMOUTH, VA 23701
US

Emergency Phone: 804-488-4411/800-424-9300 CHERMTREC

Info Phone: 804-488-4411

Cage: 60163

SHERWIN-WILLIAMS, SEAGUARD

PORTSMOUTH, VA 23704 US

Telephone: 757-397-2223

Cage: 60163

TITANIUM DIOXIDE

CAS: 13463-67-7

RTECS: XR2275000

Fraction By Weight: 20%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST; 9394

DIATOMACEOUS EARTH, FLUX-CALCINED

CAS: 68855-54-9

Fraction By Weight: 5-20%

HEAVY AROMATIC NAPHTHA (SOLVENT NAPHTHA)

CAS: 64742-94-5

RTECS: WF3100000

Fraction By Weight: 5-10%

METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA III)

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: 15.0%

OSHA PEL 200 PPM

ACGIH TLV: 200 PPM/300STEL 9394

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

METHYL N-AMYL KETONE

CAS: 110-43-0

RTECS: MJ5075000

Fraction By Weight: 10%

OSHA PEL 100 PPM

ACGIH TLV: 50 PPM; 9394

EPOXY RESIN

CAS: 25085-99-8

Fraction By Weight: 20%

CHLORITE (A MINERAL CONSISTING OF APPROXIMATELY

CAS: 1318-59-8

Fraction By Weight: 40%

VOLATILE ORGANIC CONTENT = 350 GM/L

RTECS: 9999999VO

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:BREATHING HIGH VAPOR CONCENTRATIONS
MAY PRODUCE NARCOSIS. LIQUID MAY CAUSE MINOR SKIN IRRITATION AND
DEFINITE EYE IRRITATION. CAUSES NOSE & THROAT IRRITATION.
PROLONGED/REPEATED OVEREXPOSURE TO SOLVEN TS COULD CAUSE PERMANENT
BRAIN & NERVOUSSYSTEM DAMAGE. INTENTIONAL MISUSE BY INHALING VAPOR
MAY BE HARMFUL OR FATAL.
Explanation of Carcinogenicity:MFR LISTED NO INFORMATION ABOUT THE
CARCINOGENICITY OF THIS MATERIAL. HMIS DOES NOT EXPECT IT TO BE
CARCINOGENIC.
Medical Cond Aggravated by Exposure:UNPROTECTED EXPOSURE TO DUST LEVELS
IN EXCESS OF THE PEL MAY CAUSE LUNG DISEASE (SILICOSIS).

First Aid:INHALED:REMOVE TO FRESH AIR. RESTORE BREATHING. CONSULT A
PHYSICIAN. SKIN:FLUSH W/WATER. EYE:FLUSH IMMEDIATELY W/LARGE
AMOUNTS OF WATER. CONSULT PHYSICIAN. INGESTED:GET IMMEDIATE MEDICAL
ATTENTION. - IN CASE OF EYE CONTACT,FLUSH W/WATER FROAT LEAST 15
MIN AND GET IMMEDIATE MEDICAL ATTENTION. FOR SKIN WASH THOROUGHLY
WITH SOAP & WATER.

Flash Point Method:SCC
Flash Point:24.0F,-4.4C
Lower Limits:1.1
Upper Limits:17.8
Extinguishing Media:ALCOHOL FOAM, WATER FOG, DRY CHEMICAL, CARBON
DIOXIDE
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED GAS MASK FOR FIRE
FIGHTING PERSONNEL. WATER MAY BE USED TO COOL CONTAINERS. IF WATER
IS USED, FOG NOZZLES ARE PREFERRED.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. VAPORS
MAY MIGRATE TO IGNITION SOURCE & FLASH BACK. ISOLATE FROM
HEAT,SPARKS,ELECTRICAL EQUIPMENT, & ALL OTHER IGNITIION SOURCES

Spill Release Procedures:ABSORB WITH INERT MATERIAL & DISPOSE OF IN
ACCORDANCE WITH APPLICABLE REGULATIONS OF E.P.A. AND OTHER LOCAL,
STATE & FEDERAL AUTHORITIES.
Neutralizing Agent:NO INFORMATION GIVEN BY MFR ON MSDS.

Handling and Storage Precautions:STORE AWAY FROM HEAT, SPARKS AND OPEN
FLAME. STORE IN A COOL DRY AREA W/VENTILATION SUITABLE FOR STORING
MATERIALS SHOWN IN INGREDIENTS SECTION.
Other Precautions:DO NOT BREATHE SPRAY MIST. AVOID PROLONGED SKIN
CONTACT. GROUND CONTAINERS WHILE POURING. AVOID SPONTANEOUS
COMBUSTION OF CONTAMINATED RAGS OR OTHER ORGANIC MATERIALS. EMPTY
CONTAINERS MAY RETAIN HAZA RDOUS PROPERTIES AND CAN BE DANGEROUS.

Respiratory Protection:NIOSH/MSHA APPROVED RESP TYPES SUITABLE FOR
INGREDIENTS RECOMMENDED. APPROVED CHEMICAL/MECHANICAL FILTERS
RECOMMENDED WHEN VENTILATION IS RESTRICTED. WEAR APPROPRIATE
RESPIRATOR UNLESS AIR MONITORING RECORDS EXPOSURES BELOW
APPLICABLE LIMIT
Ventilation:PROVIDE SUFFICIENT VENTILATION, IN VOLUME & PATTERN, TO
KEEP AIR CONTAMINENTS BELOW CURRENT APPLICABLE PEL/TLV.
Protective Gloves:CHEMICAL RESISTANT PLASTC OR RUBBER
Eye Protection:CHEMICAL GOGGLES, FACE SHIELD
Other Protective Equipment:AS REQUIRED TO AVOID WETTING CLOTHING. USE
PROTECTIVE CREAMS WHERE SKIN CONTACT LIKELY. EYE WASH & SAFETY
SHOWER.
Work Hygienic Practices:AVOID CONTACT WITH SKIN,EYES,CLOTHING. WASH
THOROUGHLY AFTER HANDLING. REMOVE & WASH CONTAMINATED CLOTHING
BEFORE REUSE.
Supplemental Safety and Health
NONE

HCC:F2
NRC/State Lic Num:NONE
Boiling Pt:B.P. Text:175F,79C
Vapor Density:> AIR
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:INSOLUBLE
Percent Volatiles by Volume:22.2

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:EXCESSIVE HEAT, SPARKS OR OPEN FLAME
Hazardous Decomposition Products:NO INFORMATION GIVEN BY MFR ON MSDS.
Conditions to Avoid Polymerization:WILL NOT OCCUR UNDER NORMAL
CONDITIONS.

Waste Disposal Methods:PLACE IN CLOSED CONTAINERS. DISPOSE OF PRODUCT
I/A/W FEDERAL, STATE, COUNTY & LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.